“The Rolls Royce of Wooden Jigsaw Puzzles” -Smithsonian Magazine, 1990
You can use this widget to input text into the page.
“The Rolls Royce of Wooden Jigsaw Puzzles” -Smithsonian Magazine, 1990
| Battery: | 6-Volt | 12-Volt |
|---|---|---|
| Make | Auto-Lite | Auto-Lite |
| Model | IM-100 | 11-HS |
| Plates per Cell | 15 | 9 |
| Ampere-hour Rating | 100 | 50 |
| Terminal Ground | Negative | Negative |
| Specific Gravity: | ||
| Fully Charged | 1.260 | 1.260 |
| Recharge at | 1.225 | 1.225 |
| Height | 8 5/8" | 9 7/32" |
| Length | 8 23/32" | 10 15/64" |
| Width | 7" | 6 25/32" |
| Battery Location: | Under hood - Right side | Under hood - Right side |
| Generator Specs: | ||
| Make | Auto-Lite | Auto-Lite |
| CJ-2A | GDZ 4817 | |
| Ground Polarity | Negative | Negative |
| Controlled Output: | ||
| 30 amp. | GJC 7002 | |
| 35 amp. | GDZ 4817, GDZ 6001 | GJP 7202, GJP 7402A |
| 45 amp. | GGW 4801, GGW 7404 | |
| Rotation - Drive End | Clockwise | Clockwise |
| Ratio - Generator to Crankshaft Revolutions | 1.5:1 | 1.5:1 |
| Cut-in Engine rpm | 883 | 883 |
| Control | CV Regulator | CV Regulator |
| Armature End Play | .003" to .010" | .003" to .010" |
| Brushes | 2 | 2 |
| Brush Spring Tension: | ||
| 35 to 53 oz. | GDZ 4817, GDZ 6001, GGW 4801 | |
| 18 to 36 oz. | GGW 7404A | GJC 7002, GJP 7202, GJP 7402A |
| Bearing - Drive End | Ball | Ball |
| Bearing - Commutator End | Bronze | Bronze |
| GENERATOR Specs: | ||
| Make | Delco-Remy | Delco-Remy |
| Model | 11022811 | 1102096 |
| Type | Shunt (Ventilated) | Shunt (Ventilated) |
| Rotation - Drive End | Clockwise | Clockwise |
| Armature End Play | .005" [0,13mm.] | .005" [0,13mm.] |
| Brushes | 2 | 2 |
| Brush Spring Tension | 28 oz. | 28 oz. |
| Bearing - Drive End | Ball | Ball |
| Bearing - Commutator End | Bronze | Bronze |
| REGULATOR specs: | ||
| Make | Auto-Lite | Auto-Lite |
| For GDZ 4817, GDZ 6001 | VRP-6003, VRP-4007, VBO-4601 | |
| For GGW 4801, GGW 7004A | VBO-4601C | |
| For GJC 7002 | VRX-6009 | |
| For GJC 7202, GJP 7402A | VBO-4201E-4A | |
| Type | Vibrator | Vibrator |
| Cutout Relay: | ||
| Closing Voltage @ Generator rpm | 6.3 to 6.8 @ 1000 | 12.6 to 13.6 @ 1325 |
| Reverse Current to Open | 4 to 6 amp. | 3 to 5 amp. |
| Regulated Voltage | 7.1 to 7.3 | 14.3 to 14.7 |
| Regulated Current | 49 amp. max. | 39 amp. Max. |
| REGULATOR Specs: | ||
| Make | Delco-Remy | Delco-Remy |
| Model | 1972063 | 1972029 |
| Type | Vibrator | Vibrator |
| Cutout Relay Closing Voltage | 5.9 to 6.7 | 11.8 to 13.5 |
| Regulated Voltage | 6.9 to 7.4 | 13.8 to 14.8 |
| Regulated Current | 42 to 47 | 27 to 33 |
| STARTING MOTOR Specs: | ||
| Make | Auto-Lite | Auto-Lite |
| CJ-2A | MZ-4113 | |
| Rotation - Drive End | Clockwise | Clockwise |
| Engine Cranking Speed | 185 rpm. @ room temperature | 200 rpm. @ room temperature |
| Armature End Play | .005" to .030" | .005" min. |
| Brushes | 4 | 4 |
| Brush Spring Tension | 42 to 53 oz. | 31 to 47 oz. |
| Bearings | 3 Bronze | 3 Bronze |
| Lock Test: | ||
| Temperature | 70° F. (21° C.) | 70° F. (21° C.) |
| Amps (max.) | 335 | |
| MDM-6005 | 170 | |
| MDU-7004 | 280 | |
| Volts | 2.0 | 4.0 |
| Volts | 2.0 | 4.0 |
| Stall Torque: (min.) | 6.0 lb-ft. | |
| MDM-6005 | 1.5 lb-ft. | |
| MDU-7004 | 6.2 lb-ft. | |
| No Load Test: | ||
| Temperature | 70° F. (21° C.) | 70° F. (21° C.) |
| Amps (max.) | 65 | 50 |
| Volts | 5 | 10 |
| RPM (min.) | 4300 | |
| MDM-6005 | 4400 | |
| MDU-7004 | 5300 | |
| Control Switch | Solenoid | Solenoid |
| Drive: | ||
| Type | Bendix Folo-Thru | Bendix Folo-Thru |
| Pinion Meshes | Front | Front |
| No. of Teeth - Pinion | 9 | 9 |
| No. of Teeth - Flywheel | 129 | 129 |
| Flywheel Tooth Face Width | .375" | .375" |
| STARTING MOTOR Specs: | ||
| Make | Delco-Remy | Delco-Remy |
| Model | 1108077 | 1107746 |
| Rotation - Drive End | Clockwise | Clockwise |
| Engine Cranking Speed | 185 rpm. | 185 rpm. |
| Armature End Play | .005" to .050" | .005" to .050" |
| Brushes | 4 | 4 |
| Brush Spring Tension (min.) | 24 oz. | 35 oz. |
| Bearings | 3 Bronze | 3 Bronze |
| Lock Test: | ||
| Temperature | 70° F. (21° C.) | 70° F. (21° C.) |
| Amps | 600 | 435 |
| Volts | 5.0 | 10.3 |
| RPM (min.) | 6000 | 6900 |
| Control Switch | Solenoid | Solenoid |
| COIL: | ||
| Make | Auto-Lite | Auto-Lite |
| CJ-2A early | CR-3033XE | |
| All Other Models | CR-6009, CAL-4001, CAL-4001-A, 200576, 200577, 200488 | CAF-4003, CAG-4002, 200562, 200574, 200564 |
| Amperes: | ||
| Engine Stopped | 5 @ 6.3 V | 2. to 82.9 @ 12.5V |
| Engine Idling | 2.5 | 2.8 to 2.9 |
| DISTRIBUTOR Specs: | ||
| Make | Delco-Remy | Delco-Remy |
| Model | 1112432 | 1112432 |
| Spark Advance - Centrifugal: | ||
| Start | 0° @ 425 rpm. | 0° @ 425 rpm. |
| Maximum | 10° to 12 ° @ 1950 rpm. | 10° to 12 ° @ 1950 rpm. |
| Breaker Gap | .022" | .022" |
| Cam Angle | 25° to 34° | 25° to 34° |
| Breaker Arm Tension | 19 to 23 oz. | 19 to 23 oz. |
| Condenser Capacity | .2 mfd. | .2 mfd. |
| TIMING specs: | ||
| Crankshaft | 5° BTC @ Idle | 5° BTC @ Idle |
| Mark Location: CJ-2A | Crankshaft Pulley | Crankshaft Pulley |
| Firing Order | 1-3-4-2 | 1-3-4-2 |
| SPARK PLUG specs: | ||
| Make and Model | Champion J8 | Champion J8 |
| Thread | 14 mm. | 14 mm. |
| Thread Reach | 3/8" | 3/8" |
| Gap | .030" | .030" |
| LAMP BULB TRADE NUMBERS: | ||
| Headlights | 5040-S or 6006 | 5400-S or 6012 |
| Parking Lights | 63 | 67 |
| Park and Directional Signal | 1158 | 1176 |
| Stop, Tail and Directional Signal | 1158 | 1034 |
| Indicator Lamps: | ||
| Headlight Beam | 51 | 53 |
| Directional Signal | 51 | 53 |
| Charge | 51 | 53 |
| Oil Pressure | 51 | 53 |
| Instrument Lamp | 55 | 57 |
| Flasher, Directional Signal | P229D | 524 |
| Fuse Data: | ||
| Directional Signal | SFE 14 | SFE 9 |
| Heater | SFE 14 | SFE 9 |
* Learn more about electrical from the Service Manual for Universal Jeep Vehicles page 152
RELATED VIDEOS:
Made-To-Order: Every puzzle we make is handcrafted - piece by piece. Because of this, it's impossible to know exactly how many puzzles we can cut in time for holiday delivery. Our experience allows us to make a really good, educated guess, but it's all up to our amazing team of puzzle cutters. We are committed to family fun and want your holiday season to be spectacular and magical. We'll do our best to get each and every order cut and delivered by Christmas. If we find we just can't make it happen, we'll contact you as soon as possible and send you a promise certificate to put under the tree and give you a discount of 40% off* for accepting delivery in January. If you need something for immediate delivery, please visit the InStock area of our website.
*40% off applies to puzzles with a full price over $400 (excluding Limited Editions). Other exclusions may apply.
Made To Order
Made To Order
Made To Order
Made To Order
Made To Order
| Teasers | |
|---|---|
|
Requires extra concentration |
|
Requires extra concentration & patience |
|
Requires extra concentration, patience & aspirin |
|
Requires extra concentration, patience, aspirin & Valium |
| Tricks | |
|
Hors d'oeuvres-taste Stave shenanigans. |
|
Faint of heart? This may be your limit? |
|
Be prepared to do battle. |
|
If they made Pepto Bismol for the brain, this is when you would need it. |
|
What part of 'impossible' don't you understand? |
| Tormentors | |
|
You’re feeling like a genius! |
|
You start to strain your brain! |
|
Frustration creeps in! |
|
The real agony begins! |
|
Hair pulling, expletives, and screaming ensue! Get the POINT?! |
|
If you haven't gotten the POINT yet... ☠️ |
| Troublemakers | |
|
Holy Smokes! You did it! |
|
You feel feverish as your temperature begins to rise. |
|
Requires you to loosen your collar and let out some steam. |
|
Be prepared for an eruption, you might as well throw yourself into an inferno! |
| Treats | |
|
Good for your heart. |
|
Gets your heart racing. |
|
Your heart might skip a beat. |
|
Time to monitor your heart rate. |
